| Pages:
1
..
10
11
12
13
14
15 |
Neal Johns
Super Nomad
Posts: 1687
Registered: 10-31-2002
Location: Lytle Creek, CA
Member Is Offline
Mood: In love!
|
|
See http://forums.bajanomad.com/viewthread.php?tid=46102&pag...
for post after I got home.
Neal
My motto:
Never let a Dragon pass by without pulling its tail!
|
|
|
hbmurphy
Junior Nomad
Posts: 59
Registered: 6-1-2010
Member Is Offline
|
|
Neal - Did you release the heilium out of your camper? ...and I want a re-match of the race out of the bog!
|
|
|
Neal Johns
Super Nomad
Posts: 1687
Registered: 10-31-2002
Location: Lytle Creek, CA
Member Is Offline
Mood: In love!
|
|
Ken Cooke
Yep, the Tacoma is weight overloaded. Due to that, over the last 11 years carrying a pop-top camper, I have two rear wheel bearing failures.
This trip is the first time a ring and pinion has given any trouble.
The tie rods bindings were a result of the short tow strap necessitated by the sharp turns in the road and the rocks hit as a result of limited
steering and my incompetence.
hbmurphy
That was no race, it was a Turtle Mud Crawl.
Helium? It was filled with hot air. 
My motto:
Never let a Dragon pass by without pulling its tail!
|
|
|
David K
Honored Nomad
Posts: 64852
Registered: 8-30-2002
Location: San Diego County
Member Is Offline
Mood: Have Baja Fever
|
|
One thing for sure Ken, nobody was in 2WD in there!!!  
Well, I take that back... while Neal was in '4WD' on his transfer case, coming out he was a FRONT wheel drive Tacoma after the ring and pinion blew
out, and he removed the drive shaft!
[Edited on 6-6-2010 by David K]
|
|
|
Ken Cooke
Elite Nomad
Posts: 8946
Registered: 2-9-2004
Location: Riverside, CA
Member Is Offline
Mood: Pole Line Road postponed due to injury
|
|
| Quote: | Originally posted by David K
One thing for sure Ken, nobody was in 2WD in there!!!
Well, I take that back... while Neal was in '4WD' on his transfer case, coming out he was a FRONT wheel drive Tacoma after the ring and pinion blew
out, and he removed the drive shaft!
[Edited on 6-6-2010 by David K] |
While I was exploring the borderlands with my wife Leidys this weekend, I was thinking about Neal and his Tacoma. I even saw a previous-generation
Tacoma (w/Camper) on the I-5 traveling northbound, but it wasn't him. Good to hear he made it home!
|
|
|
surfer jim
Super Nomad
Posts: 1891
Registered: 8-29-2003
Location: high desert
Member Is Offline
|
|
That "bog" looks worse than the hill climbs.
Did the mud wash off itself or get dried on ? In either case what a mess.
|
|
|
edm1
Senior Nomad
Posts: 568
Registered: 8-23-2006
Location: Oak Hills, Ca
Member Is Offline
|
|
| Quote: |
Did the mud wash off itself or get dried on ? In either case what a mess. |
Surprisingly, the mud must have washed off itself; I checked the undercarriage of my motorhome this weekend and NO MUD.
Instead I found many loose things and a cracked panhard bar mount and braces up front. Tighetened them and a few beads of weld and I'm ready for Shell
Island. My mudguards still need straightening; my rear bumper is 5 inches higher now, with the fiberglass rear quarters trimmed to an angle pointing
to the higher rear bumper.
Art
|
|
|
David K
Honored Nomad
Posts: 64852
Registered: 8-30-2002
Location: San Diego County
Member Is Offline
Mood: Have Baja Fever
|
|
You have one of those 'self-cleaning' 4WD vans!
My rear bumper is almost back to where it started... self repairing bumper (with memory in the steel... what will Toyota think of next???)! 
|
|
|
Steve in Oro Valley
Nomad
Posts: 105
Registered: 11-14-2002
Location: Near Tucson
Member Is Offline
|
|
Very interesting trip report...
Was that a Pacific tree frog you caught on camera?
After my life experiences with water in bearings and axles and with overloaded suvs, I would be very happy to walk the last 2 miles or so to explore
close up and perhaps sneek up on some wildlife...
In the cool seasons of Baja Arizona, I make it a practice of driving to remote canyons and mountains and putting in about 8-10 miles per week hiking
...
But I understand the pull of being one with the suv and testing the limits of machinery.....
Thanks for the great pictures of the blue palms and dodder covered copalquines...
Steve in Oro Valley
|
|
|
Cyanide41
Nomad
Posts: 303
Registered: 1-7-2009
Location: Tijuana
Member Is Offline
|
|
Aw crap! How the hell did I miss this? I mean not only did I miss the event, I missed the entire thread! Looks like a good time, sorry I missed it.
|
|
|
hbmurphy
Junior Nomad
Posts: 59
Registered: 6-1-2010
Member Is Offline
|
|
| Quote: | Originally posted by Steve in Oro Valley
Very interesting trip report...
Was that a Pacific tree frog you caught on camera?
After my life experiences with water in bearings and axles and with overloaded suvs, I would be very happy to walk the last 2 miles or so to explore
close up and perhaps sneek up on some wildlife...
In the cool seasons of Baja Arizona, I make it a practice of driving to remote canyons and mountains and putting in about 8-10 miles per week hiking
...
But I understand the pull of being one with the suv and testing the limits of machinery.....
Thanks for the great pictures of the blue palms and dodder covered copalquines...
Steve in Oro Valley |
Frog
I don't know what kind of frog it was! ?
Water Damage
For those of you that have not modified your rear breather like this:
You may want to change out your diff lube. If it is a limited slip differential - remember to use the right gear lube or your rear will chatter and I
am not talking about the green house gas type!
On most Toyotas (I am partial) the front breather is located near or above the same vertical hieght as the intake so, you should be good there.
This lube change is cheap insurance to a long differential life.
If you are interested in making your truck more swamp proof, look at this thread...
Diff Breather Mod
[Edited on 6-9-2010 by hbmurphy]
[Edited on 6-9-2010 by hbmurphy]
|
|
|
David K
Honored Nomad
Posts: 64852
Registered: 8-30-2002
Location: San Diego County
Member Is Offline
Mood: Have Baja Fever
|
|
Um, Paul... Since I was as much underwater as you... Is the diff. fluid change something I need to have done (soon)?
|
|
|
hbmurphy
Junior Nomad
Posts: 59
Registered: 6-1-2010
Member Is Offline
|
|
After taking a short bath…
This truck's front differential looked like this about 100 miles later. I place the blame on 4WheelParts for not putting the breather back on the
front diff housing….
Unrelated to Mud but still interesting regarding breaking a ring and pinion...
This is what my gear looked like after I wheeled 10 miles in reverese after breaking the first time...
climbing this wall at Aftershock (Hammers - Johnson Valley)
so, I realize that many may think "I go through stuff like that all the time." For a little work you can protect your truck from falling victim to a
contaminated diff.
[Edited on 6-9-2010 by hbmurphy]
|
|
|
Steve in Oro Valley
Nomad
Posts: 105
Registered: 11-14-2002
Location: Near Tucson
Member Is Offline
|
|
Good info on diff vent tubes!
About 2 months ago I drove on a remote 4wd trail in Fresnal Canyon ( Baboquivari Mtns on the reservation side SW of Tucson) and went thru water (less
than 18 inches on hard substrate) several times and a little later I could smell that cooking lube grease smell when the breeze shifted.....
It occurred that I may have sucked in some water into the axle differentials and the smell was venting out as it heated up....
I have a 99 Cherokee 4X4 with a Detroit "soft" locker in the rear...
Does that smell of burning diff lube indicate that I may have to repack all the bearings and change out all the lubes??
What is your experience?
Steve in Oro Valley
|
|
|
Barry A.
Select Nomad
Posts: 10007
Registered: 11-30-2003
Location: Redding, Northern CA
Member Is Offline
Mood: optimistic
|
|
A simple check of your diff fluid can be made by unscrewing the plug and looking inside with a flashlite, or take a sample, or both--------if the lube
is milky it is contaminated and needs to be changed out pronto. If it is clear with no clouding, then it is probably ok.
If in doubt, just change it with the PROPER fluid. (very cheap insurance)
Barry
|
|
|
CG
Junior Nomad
Posts: 68
Registered: 1-1-2006
Member Is Offline
|
|
I had my diff oil changed when I got back just to make sure. I didn't have any water in there & I was in there longer than the other trucks. You
guys might want to check to make sure, but it usually only gets in when you sit in the water for a time rather than just driving through.
I'm going to make sure my breather tubes are run up better anyways just to be ready for next time!
I had the whole inside of my car cleaned to get the muddy water out. They took out the seats and lifted the carpeting to make sure they got it all
When bad men combine, the good must associate; else they will fall one by one, an unpitied sacrifice in a contemptible struggle. Edmund Burke
|
|
|
Baja12valve
Nomad
Posts: 185
Registered: 7-12-2006
Location: Oak View
Member Is Offline
|
|
| Quote: | Originally posted by Steve in Oro Valley
Good info on diff vent tubes!
About 2 months ago I drove on a remote 4wd trail in Fresnal Canyon ( Baboquivari Mtns on the reservation side SW of Tucson) and went thru water (less
than 18 inches on hard substrate) several times and a little later I could smell that cooking lube grease smell when the breeze shifted.....
It occurred that I may have sucked in some water into the axle differentials and the smell was venting out as it heated up....
I have a 99 Cherokee 4X4 with a Detroit "soft" locker in the rear...
Does that smell of burning diff lube indicate that I may have to repack all the bearings and change out all the lubes??
What is your experience?
Steve in Oro Valley |
If you have a lot of water in the oil, the oil will look like a foamy coffee milkshake. The water will emulsify into the oil and cause it will lose
all lubricity. If it is like that , change it, drive on it for a few days and change it again until it is clear. If you do it soon enough, all
bearings and other parts will be OK.
|
|
|
Barry A.
Select Nomad
Posts: 10007
Registered: 11-30-2003
Location: Redding, Northern CA
Member Is Offline
Mood: optimistic
|
|
I actually does not take much water-----a tablespoon of water will foul up things royally.
Barry
|
|
|
edm1
Senior Nomad
Posts: 568
Registered: 8-23-2006
Location: Oak Hills, Ca
Member Is Offline
|
|
Changed all fluids this weekend - tranny, xfer case, front/rear diff - except engine oil (I changed oil before the trip) and steering fluid. Also
repacked all wheel bearings. There wasn't any sign of oil, but what the heck I already opened the hubs to check for water, may as well repack them.
My breather tubes are both above the frame rails so I think that's good enough. My front differential was a little overfilled during the trip, and it
vented probably a pint on the trail (CG thought it was steering fluid).
Also having the two tires re-mounted/balanced this weekend (the two that we had to reseat the beads - I'm sure there's dirt and maybe water (or worse
gasoline :-) inside. May as well have the rest of the wheels rebalanced (lost many chunks of the tires). And be ready for Shell Island soon.
[Edited on 6-10-2010 by edm1]
|
|
|
Barry A.
Select Nomad
Posts: 10007
Registered: 11-30-2003
Location: Redding, Northern CA
Member Is Offline
Mood: optimistic
|
|
Well done, edm 1-----------
A sure way to eliminate residual gasoline in the tire is to use the Neal John's method-------a match to the valve stem. Tried and true. I like it!!!
(disclaimer: don't do this at home)
Barry
|
|
|
| Pages:
1
..
10
11
12
13
14
15 |
![[*]](images/xmbforum/default_icon.gif){kind=icon}
