Garry
Nomad
Posts: 100
Registered: 11-1-2002
Location: SACTO, CA
Member Is Offline
|
|
Smoking Fish
Smoking Fish
At Home
FNH-00325
Note:
If you are planning to can the smoked fish, please refer to FNH‑00223, Home Canning Smoked Fish and Home Smoking Fish For Canning for
recommendations for smoking fish for canning and for directions for canning smoked fish.
Introduction
Producing a high quality home-smoked fish is a popular recreational activity and a point of pride for many Alaskans. In earlier times, smoking was a
form of food preservation; large amounts of salt and long smoking times were used to help preserve the fish. Now fish is smoked more for flavor and
appearance. Today’s lightly salted and smoked fish is not a preserved product; the amounts of salt and smoke used are NOT sufficient to prevent
bacterial spoilage. Most food poisoning bacteria can and will grow under the conditions normally found in preparation and storage of smoked fish.
Clostridium botulinum, the bacteria that may cause botulism, is the most harmful of these bacteria.
A safe home-smoked product requires a good understanding of the procedures and precautions needed to prevent food poisoning. This bulletin explains
why certain procedures must be followed and precautions taken to prepare safe high quality smoked fish.
The Smoking Process
Smoking fish usually requires five steps. These are:
• PRODUCT PREPARATION
• SALTING OR BRINING
• EQUILIBRATION AND DRYING
• SMOKING AND COOLING
(hot or cold smoke)
• PRODUCT PACKAGING and STORAGE
Each step is critical to producing a good quality and safe product. It is important to follow the steps outlined to minimize the potential for
bacterial spoilage and food poisoning.
Product Preparation
Almost any fish can be smoked. Fatty fish, such as salmon and black cod, can be brined and smoked much easier than lean fish. Low fat fish, such as
grayling and halibut, are more difficult to smoke because these fish absorb salt quickly, and it is easy to get the flesh too salty.
Only high quality fresh or frozen fish should be used for smoking. Using poor quality, freezer burned fish will produce a poor smoked product. Smoking
will not hide poor quality; it will call attention to the problem.
When preparing fish for smoking, it is important to keep the preparation area clean and sanitary. Keeping the work area, cutting boards, knives and
hands clean will help prevent bacterial contamination. Do not, under any circumstances, handle raw fish where the finished smoked product is kept.
This could result in cross-contamination; spoilage bacteria could transfer from the raw to the finished product.
Clean all fish carefully to remove slime, blood and harmful bacteria. Then fillet or split the fish, leaving the skin on the fillet. Cut the fillet
into uniform pieces so that no parts will get oversalted.
Pieces should not be more than one inch thick. Larger pieces of fish may spoil during the smoking process.
During preparation the fish should be kept as cool as possible. This will help keep down bacterial growth and spoilage. The ideal temperature for
holding fish during this stage of the process is below 38° F. Home refrigerators are often 40° F or higher. Check the refrigerator temperature
with an appliance thermometer and adjust controls as needed.
2use. This helps reduce bacterial growth and increases salt uptake into the fish. Place the fish in the brine for 20 minutes to 3 hours depending on
the desired taste. Weaker brines (using less than 11⁄2 pounds of salt per gallon) can be used with correspondingly longer soak times.
After keeping fish in brine for long periods of time (1 hour or longer), the fish should be “freshened” by soaking in fresh water to remove the excess
brine. This usually takes 30 to 60 minutes for most products. For a lightly salted product (brining times less that 1 hour), a fresh water rinse is
sufficient to remove excess brine.
The brine-to-fish ratio should be 3 parts brine to 1 part fish. For example, 10 pounds of fish will require 30 pounds of brine (approximately 4
gallons; 1 gallon
of brine weighs about 8 pounds).
Drying
Once the fish has been brined, it is usually dried before smoking. Drying accomplishes two things. It allows the salt to penetrate and to become
evenly distributed throughout the flesh of the fish (equilibration).
Secondly, the surface of the fish dries to form a “pellicle” or tough shiny coat. The pellicle seals in moisture and makes the appearance of the
finished product much better.
Refrigerate the fish while waiting for salt penetration
and to start surface drying. Keep temperatures below 38° F. Equilibration may require anywhere from 2 to 24 hours depending on fish thickness (6 to 8
hours for a 1-inch thick fillet).
Forming a pellicle requires warmer temperatures and is usually done in the smoker just prior to smoking. It may take 30 minutes to 3 hours to form a
good pellicle. This depends on the smoker temperature
and humidity. If possible, avoid the longer times because the potential for bacterial spoilage becomes greater.
Smoking
The fourth step of the process is smoking. There are many recipes for smoking using different times and temperatures, but only two basic methods:
1. “Hot” smoke: the internal product temperature reaches 160° F and higher. A cooked, smoked product such as kippers is produced.
Another common problem is parasites. Many fish contain tapeworms and nematodes that can survive some low salt brining and temperature smoking methods
and can cause serious health problems. These parasites can be destroyed by freezing the raw product at a temperature of 0° F for two weeks or longer,
before salting and smoking. When freezing the product in a home freezer, it may take several days to reach 0° F throughout the entire fish; the more
food you put in the freezer at one time, and the thicker the pieces of food are, the longer it will take to freeze the food.
(If you have several fish to freeze at one time, it would be a good idea to borrow or rent additional freezer space to be sure the fish will freeze
within a reasonable time.)
For hot smoked product (see section on smoking) the internal temperature of the fish is raised to at least 160° F for bacterial reduction, which
exceeds the 150° F required to kill parasites. Therefore, only fish intended for a cold smoke process must be frozen prior to processing.
Salting
The second step in the smoking process is salting the fish. Salting was once the preservation step in smoking. High levels of salt inhibited bacterial
growth and made the product safe. But, with today’s concern over salt in the diet, it is used only as a flavoring agent, not as a preservative.
Salting can be accomplished using either a strong salt solution (brine) or dry salt. For most recipes, brining gives a more uniform salting and is
easier to prepare and use. Dry salting requires considerable experience before consistent results are obtained.
Brines can be prepared by dissolving salt in fresh water. Use only kosher salt, vacuum dried salt, dairy salt, pickling and canning salt, or flake
salt for brines. These are pure salts. Avoid rock salt, sea salt and iodized salt because these contain impurities
and additives that can cause bitterness and off flavors. Curing salts should also be avoided since they contain nitrites. It is difficult to get an
even distribution of nitrite throughout the fish under home conditions.
Any strength brine may be prepared. The brine used in our experiments is made by dissolving 11⁄2 pounds of salt per gallon of water. Once the
brine is made it should be chilled to 38° F or lower before
3
2. “Cold” smoke: the internal product temperature is below 90° F. The resulting product is a raw, smoked fish such as lox or Nova Scotia style salmon.
For most people, hot smoking is the most popular form and easiest to produce in home smokers.
Also, the temperatures recommended
for hot smoking are high enough to kill most bacteria. Cold smoke temperatures are not hot enough to kill bacteria and actually may promote growth of
bacteria.
Recommendations for each smoking
method:
Hot Smoking —
• Cook the fish to 160° F internal temperature (use a thermometer) for at least 30 minutes at some time during the smoking cycle, preferably
toward
the end. This temperature will kill most food spoilage bacteria and combined with proper refrigeration will ensure a safe product. A typical fish
smoking cycle (figure 1) should bring the internal temperature of the fish to 160° F within 6 to 8 hours after placing it in the smoker.
Use a standard meat thermometer to monitor internal temperature. Insert the thermometer into the thickest part of the fish.
• It is best to wait 3 to 5 hours before raising the fish internal temperature to 160° F. This will prevent curd formation and “exploded” pieces that
occur when the temperatures are elevated too quickly.
• If the smoker does not heat hot enough to produce an internal temperature of 160° F in the fish, the smoked fish can be transferred to a home oven
set at 300° F for a final heat treatment. Bring internal fish temperature to 160° F and bake for at least 30 minutes. Adjust the oven temperature as
needed throughout this baking period to maintain the 160° F internal temperature. Be sure that hands, utensils and work surfaces are clean when
transferring fish from smoker to oven to avoid cross-contamination.
Figure 1. Typical internal fish temperature during smoking cycle.
Source: Kenneth S. Hilderbrand, Jr., Smoking Fish at Home Safely, Pacific Northwest Extension publication PNW 238. Reprinted September 1996
• Depending on the desired finished product, smoking should take anywhere from 6 to 15 hours. Shorter cooking times will result in more moist finished
products.
Cold Smoking —
If cold-smoked fish will not be cooked prior to eating, the freezing step (page 2) is necessary to destroy harmful parasites that may be present in
uncooked fish.
• Temperature control is very critical. Never allow
the internal product temperature to exceed 90° F. At 95° F, the fish will start to cook.
• It is difficult to cold smoke in areas of high humidity. When relative humidity cannot be reduced below 75 percent at air temperatures below 85° F,
then cold smoking is not possible.
• Depending on the desired finished product, smoking will take anywhere from 16 hours to 7 days.
Caution: The entire cold smoking process takes place in the temperature “danger zone” (40° F to 140° F). Therefore, this product could spoil or become
unsafe to eat before it is fully smoked.
4
MUST be kept under refrigerated or frozen storage. NEVER leave smoked fish at room temperatures. Please refer to FNH-00221, Storing and Mailing Vacuum
Packaged Fish.
Brine Recipes
Heavy Salt Brine: 21⁄2 pounds (41⁄2 cups) of salt per gallon of water.
Medium Salt Brine: 11⁄2 pounds (21⁄2 cups) of salt per gallon of water.
Slowly pour salt into water stirring constantly. Chill before using. Sugars and pickling spices can also be added to give extra flavors to the
finished product. Vary the ingredients and proportions to suit your taste:
— Heavy salt brine, add 11⁄2 cups white or brown sugar per gallon of water.
— Medium salt brine, add 1 cup white or brown sugar per gallon of water.
Spices - amounts per gallon of water
Bay Leaf-------------------50 leaves, crushed
Pepper --------------------8 teaspoons
Mace-----------------------2 tablespoons
Allspice-------------------7 teaspoons
Cloves---------------------2 tablespoons
Juniper berries----------2 tablespoons, crushed
Written by Chuck Crapo, Seafood Quality Specialist, Marine Advisory Program, University of Alaska Fairbanks. Revised June 1993 by Barbara Greene,
EFNEP/Nutrition Coordinator. Revised in 1998 by Bret Luick, EFNEP Coordinator.
Product Storage
The final and most important step in producing smoked fish is product storage. Most smoked products have had no preservation step. There is not enough
salt, smoke or heat to preserve the product. The potential for bacterial spoilage and botulism exists.
After the fish has been smoked, allow it to cool to room temperature (this will prevent condensation) and then do one of the following:
1. Wrap and refrigerate below 38° F until consumed.
Use a good plastic wrap and/or aluminum
foil. Lightly salted and smoked product can last as long as 10 to 14 days in the refrigerator.
(Again, make sure that your refrigerator can maintain proper temperatures.)
2. Wrap and freeze. Use a good freezer wrap and aluminum foil to protect the product. Properly protected smoked salmon will last for 2 to 3 months.
You MUST handle the finished product using one of these options in order to keep the smoked fish SAFE. Another popular method for storing smoked fish
is sealing the products in vacuum packages. Home style vacuum packages make it easy to protect smoked fish. BUT, vacuum packaged smoked fish
Thanks to Cooperative Extension Service Home Economists Kristy Long and Pat Aune, Marine Advisory Program (MAP) Chair and Seafood Technology
Specialist Dr. Donald Kramer, Professor of Fisheries (Retired) John Doyle and MAP Agent Brian Paust. Their review and comments assure the reliability
of the contents of this publication.
Smoked fish also may be canned. Please refer to FNH-00223, Home Canning Smoked Fish & Home Smoking Fish For Canning for directions.
7-89/CC-BL/1750 Reprinted June 2007
The University of Alaska Fairbanks Cooperative Extension Service programs are available to all, without regard to race, color, age, sex, creed,
national origin, or disability and in accordance with all applicable federal laws. Provided in furtherance of Cooperative Extension work, acts of May
8 and June 30, 1914, in cooperation with the U.S. Department of Agriculture, Pete Pinney, Interim Director, Cooperative Extension Service, University
of Alaska Fairbanks.
The University of Alaska Fairbanks is an affirmative action/equal opportunity employer and educational institution.
© 2007 University of Alaska Fairbanks This publication may be photocopied or reprinted in its entirety for noncommercial purposes.
Visit the Cooperative Extension Service Web site at
www.uaf.edu/ces
SMOKING FISH ATAT HOME
For more information contact Kristy Long, Extension Foods Specialist at 907-474-7974 or ffkal@uaf.edu.
|
|
|
Udo
Elite Nomad
Posts: 6346
Registered: 4-26-2008
Location: Black Hills, SD/Ensenada/San Felipe
Member Is Offline
Mood: TEQUILA!
|
|
This has to be the most elaborate sea-food smoking answer I have seen in my life.
I have an original set of plans and instructions on how to build several smokers (hot or cold), from a December 1961 Field and Stream magazine. It
also has instuctions on brining and curing. If anyone is interested, I'll see
if I can figure out how to scan 12 pages into my word processor (I think that is actually the easy part). Then cut and paste them on the board.
However, the simplest smoker I have ever seen built was by Alton Brown of the food network: Use two large clay flower pots, one on top of the other.
Put a small round electric stove on the inside bottom clay pot, and use old BBQ grilles in the pots to place your fish. Wet some wood chips, and keep
adding as the chips burn out (about every three hours). The fish should be done in about 6 hours.
Just to let everyone know, I KNOW NOTHING ABOUT SMOKING FISH, I'm just willing to share what information I have.
Udo
Youth is wasted on the young!
|
|
|
nancyinpdx
Nomad
Posts: 233
Registered: 1-16-2009
Member Is Offline
Mood: muy eccentrica
|
|
If ya smoke too much fish do you get hallucinations and dance around the beach in a speedo and 'mantyhose'? ja ja!
sorry... i'm an extremely eccentric weirdo... just can't help it
|
|
|
dtbushpilot
Ultra Nomad
Posts: 3288
Registered: 1-11-2007
Location: Buena Vista BCS
Member Is Offline
Mood: Tranquilo
|
|
| Quote: | Originally posted by nancyinpdx
If ya smoke too much fish do you get hallucinations and dance around the beach in a speedo and 'mantyhose'? ja ja!
sorry... i'm an extremely eccentric weirdo... just can't help it |
I've tried to smoke fish many times and no matter how hard I puff I can't seem to keep it lit.....never could figure out why people make such a fuss
over it.......dt
|
|
|
BajaBruno
Super Nomad
Posts: 1035
Registered: 9-6-2006
Location: Back in CA
Member Is Offline
Mood: Happy
|
|
It was good of Garry to give credit to The University of Alaska Fairbanks Cooperative Extension Service for this article. The original PDF document
can be found at:
http://www.uaf.edu/ces/publications/freepubs/FNH-00325.pdf
The PDF includes a chart of cooking temps.
Thanks, Garry. I've always wanted to try this, but the process does seem a bit intimidating to get right.
Christopher Bruno, Elk Grove, CA.
|
|
|
|
![[*]](images/xmbforum/default_icon.gif){kind=icon}
