| Pages:
1
2 |
BigOly
Senior Nomad
Posts: 523
Registered: 10-1-2010
Location: Los Barriles, Bandon
Member Is Offline
Mood: Easy Birder
|
|
solar question
A friend gave me a new 100 Watt solar panel. Can I use this to keep a 12 volt deep cycle battery charged for my generator? Maybe I need a
"controller"?
|
|
|
bajaguy
Elite Nomad
Posts: 9247
Registered: 9-16-2003
Location: Carson City, NV/Ensenada - Baja Country Club
Member Is Offline
Mood: must be 5 O'clock somewhere in Baja
|
|
Controllers
http://www.harborfreight.com/30-amp-solar-charge-controller-...
https://www.amazon.com/dp/B00FB3OPKM?psc=1
|
|
|
willardguy
Elite Nomad
Posts: 6451
Registered: 9-19-2009
Member Is Offline
|
|
whats the panel voltage?
|
|
|
Russ
Elite Nomad
Posts: 6742
Registered: 7-4-2004
Location: Punta Chivato
Member Is Offline
|
|
Yep it should work if it's a 12v panel and you go thru a cheep charger. I remember paying $12 awhile ago for one like this.
https://www.amazon.com/Schumacher-SPC-7A-Solar-Charge-Contro...
I use it for boat, quad, gen and camper batteries. The ones above appear to be a higher quality though and not much more $
Bahia Concepcion where life starts...given a chance!
|
|
|
BigOly
Senior Nomad
Posts: 523
Registered: 10-1-2010
Location: Los Barriles, Bandon
Member Is Offline
Mood: Easy Birder
|
|
Panel volt says 17.48. Can you tell me the distance I can have between the controller and the battery? I tried to use a distance calculater but it's
above my pay grade.
|
|
|
larryC
Super Nomad
Posts: 1496
Registered: 8-11-2008
Location: BoLA
Member Is Offline
|
|
For a 100 watt panel I would use a 10 amp rated controller. Should work just fine. The longer the wire run the less amps will actually get to the
battery so keep the run as short as possible. In the real world that 100 watt panel will only give you about 77 watts so a 10 amp controller is a
little bit of over kill but better to go a little big than a little small. Morning star makes some good small controllers. I used a really cheap
controller in my garage to maintain some batteries but the cheapy controller failed and ruined a couple of batteries which cost me over a $100 to
replace so no more cheapies for me.
Off grid, 12-190 watt evergreen solar panels on solar trackers, 2-3648 stacked Outback inverters, 610ah LiFePo4 48v battery bank, FM 60 and MX60
Outback charge controllers, X-240 Outback transformer for 240v from inverters, 6500 watt Kubota diesel generator.
|
|
|
BajaNomad
|
Thread Moved
3-25-2017 at 07:33 PM |
Alm
Ultra Nomad
Posts: 2729
Registered: 5-10-2011
Member Is Offline
|
|
Quote: Originally posted by BigOly  | | Panel volt says 17.48. Can you tell me the distance I can have between the controller and the battery? I tried to use a distance calculater but it's
above my pay grade. |
This is a nominal 12V panel. Any PWM controller from 7-10A will do. Leaving 20% margin is recommended, so it makes it 10A. Expect to pay $30 or more.
Stay away from cheap cr-ap on Amazon or Chi-bay.
I would get another 2 panels like this, and use Grape PWM controller from Home Depot, $40. 300W array with 2*6V batts would keep you afloat on most
days, and you would only use generator for high-current loads like microwave. Batteries would be happier too, with generator alone they are never
fully charged.
Max distance depends on the wire gauge.
|
|
|
larryC
Super Nomad
Posts: 1496
Registered: 8-11-2008
Location: BoLA
Member Is Offline
|
|
Alm
He only wants to keep a generator battery charged not his house batteries.
Never heard of a grape charge controller, is it new?
Off grid, 12-190 watt evergreen solar panels on solar trackers, 2-3648 stacked Outback inverters, 610ah LiFePo4 48v battery bank, FM 60 and MX60
Outback charge controllers, X-240 Outback transformer for 240v from inverters, 6500 watt Kubota diesel generator.
|
|
|
willardguy
Elite Nomad
Posts: 6451
Registered: 9-19-2009
Member Is Offline
|
|
| Quote: Originally posted by Alm | | Quote: Originally posted by BigOly | | Panel volt says 17.48. Can you tell me the distance I can have between the controller and the battery? I tried to use a distance calculater but it's
above my pay grade. |
This is a nominal 12V panel. Any PWM controller from 7-10A will do. Leaving 20% margin is recommended, so it makes it 10A. Expect to pay $30 or more.
Stay away from cheap cr-ap on Amazon or Chi-bay.
I would get another 2 panels like this, and use Grape PWM controller from Home Depot, $40. 300W array with 2*6V batts would keep you afloat on most
days, and you would only use generator for high-current loads like microwave. Batteries would be happier too, with generator alone they are never
fully charged.
Max distance depends on the wire gauge. |
what part of this don't you understand? 
solar question
"A friend gave me a new 100 Watt solar panel. Can I use this to keep a 12 volt deep cycle battery charged for my generator? Maybe I need a
"controller"? "
|
|
|
Alm
Ultra Nomad
Posts: 2729
Registered: 5-10-2011
Member Is Offline
|
|
Willardguy, from my experience, when somebody asks whether they need a controller with 100W panel, they need more than a simple "yes". The questions
following the initial question confirm that they do.
Larry - yes, it's new. 40A PWM with Bluetooth monitoring, Tcomp and adjustable setpoints. Better bang for the buck than Morningstar.
[Edited on 3-27-2017 by Alm]
|
|
|
willardguy
Elite Nomad
Posts: 6451
Registered: 9-19-2009
Member Is Offline
|
|
| Quote: Originally posted by Alm | Willardguy, from my experience, when somebody asks whether they need a controller with 100W panel, they need more than a simple "yes". The questions
following the initial question confirm that they do.
Larry - yes, it's new. 40A PWM with Bluetooth monitoring, Tcomp and adjustable setpoints. Better bang for the buck than Morningstar.
[Edited on 3-27-2017 by Alm] |
all he wants to do is maintain a 12 volt generator battery!
|
|
|
Alm
Ultra Nomad
Posts: 2729
Registered: 5-10-2011
Member Is Offline
|
|
He wants to maintain it with solar. And it appears that he doesn't know how. Wouldn't have asked questions here if he did, would he?
[Edited on 3-27-2017 by Alm]
|
|
|
willardguy
Elite Nomad
Posts: 6451
Registered: 9-19-2009
Member Is Offline
|
|
| Quote: Originally posted by Alm |
He wants to maintain it with solar. And it appears that he doesn't know how. Wouldn't have asked questions here if he did, would he?
[Edited on 3-27-2017 by Alm] |
|
|
|
SteveWil
Junior Nomad
Posts: 29
Registered: 7-9-2010
Member Is Offline
|
|
Get the cheap controller and you can use 14 gauge wire for 200 feet (400 foot round trip), I would use 12 gauge for longer run. mount the controller
close to the battery ( 10 feet or less). This is for just maintaining a battery and not trying to get the most out of the systems.
|
|
|
Alm
Ultra Nomad
Posts: 2729
Registered: 5-10-2011
Member Is Offline
|
|
Get cheap controller and treat your battery as disposable, or get a better controller and keep your battery for years. Your choice.
Do your math. Using 14 gauge wire 200ft one-way distance, a 100W panel will work as 15W - which might be enough, give small battery size. Or it might
be not. The objective of maintenance is keeping voltages where they should be. If the weather and self-discharge require min 50W panel, then you need
min 50.
IMO, the best place to ask questions about small solar is rv.net. Not here.
[Edited on 3-27-2017 by Alm]
|
|
|
SteveWil
Junior Nomad
Posts: 29
Registered: 7-9-2010
Member Is Offline
|
|
I disagree about the cheap controller, in THIS situation it will do the job just as well as a high priced controller.
Your math is good but, all he needs in this situation is a 15W changing system, to maintain the starting battery. We may be thinking of maintaining
the battery differently. I am thinking the solar will only be used to keep the battery at a float stage, when the generator is started the generator
will replace the power used to start the generator. So very little power will ever be needed from the solar panel.
|
|
|
Alm
Ultra Nomad
Posts: 2729
Registered: 5-10-2011
Member Is Offline
|
|
With cheap controller the chances of failure are too high. Besides, they often have Float fixed at the wrong value and no temperature compensation. By
cheap I mean anything unknown and under $30-35 per 10A unit. Batteries cost more than that, plus inconvenience.
Morningstar 10 @$50 is good enough. Grape 40 is nicer and cheaper, though it's new (a year?), short track record. I recall some $30-ish models at
Amazon with relatively positive reports but I wouldn't trust those as much as MS or Grape. $50 units can fail too, but the lower you go, the less
you'll be getting.
Speaking of maintenance... Generator, when run only occasionally and for a short time (otherwise they do indeed need more solar), will not bring
battery back to 99.9% full. This is the job for maintenance charger and it should be powerful enough to bring it up to 14.x once a day, and then keep
it at Float. It's better to have more power than not enough.
|
|
|
del mar
Banned
Posts: 1057
Registered: 7-23-2016
Location: the cantina of course
Member Is Offline
Mood: lil' fuzzy
|
|
 ...best to just let it go steve.......
|
|
|
SteveWil
Junior Nomad
Posts: 29
Registered: 7-9-2010
Member Is Offline
|
|
Running low on popcorn? 
$50 is cheap
|
|
|
Bajavanadu
Junior Nomad
Posts: 66
Registered: 8-3-2015
Location: San diego
Member Is Offline
|
|
I have a 50 watt panel charging my deep cycle with a cheapo 10 amp controller, it puts out 2-3 amps per hour in good sun. A 10 amp controller will
be just fine for your panel. Amazon.com has them for 15-20 bucks.
|
|
|
| Pages:
1
2 |
![[*]](images/xmbforum/default_icon.gif){kind=icon}
